Assessing the potential of sewage sludge-derived biochar as a novel phosphorus fertilizer: Influence of extractant solutions and pyrolysis temperatures.

Sewage sludge-derived biochar (SSB) is a phosphorus (P) source with potential to replace soluble P fertilizers. However, SSB presents a diversity of P compounds, mainly in mineral forms with different degrees of chemical stability. This hinders the prediction of P bioavailability. In the present study we evaluated P solubility and bioavailability using different chemical extractants. Additionally, the relationships between extractable P and physicochemical properties were evaluated for SSB obtained over a wide range of temperatures (200 °C; 300 °C; 500 °C and 600 °C). Available phosphorus content was extracted using 2% citric acid (P-CA), neutral ammonium citrate + water (P-NAC) and Mehlich 1 solution (0.0125 mol L-1 H2SO4 + 0.050 mol L-1 HCl). Physicochemical properties and extractable P were strongly affected by pyrolysis temperature. Higher pyrolysis temperature resulted in increased pH, BET surface area, pore volume, ash, fixed carbon, Ca, Mg and Zn contents, as well as formation of stable Ca minerals (calcite and oxalate). The total P content increased with pyrolysis temperature (≥300 °C). Nevertheless, the solubility of biochar-P in the extractants presented different trends with temperature. The P-NAC content reached a maximum (79% of TP) at 300 °C and then declined at higher temperatures. Only at 600 °C P-CA and available P were affected by the temperature, where the P-CA increased and available P decreased. Therefore, it is recommended that the P solubility in different extractants should be considered when using SSB as an alternative to inorganic P fertilizers.

Sewage Sludge Biochar Effects on Phytopathogenic Fungi and Beneficial Microorganisms

Abstract Biochar (BCH) is a solid product, rich in carbon, obtained by heating biomass under controlled conditions of oxygenation, in a process known as pyrolysis. Its benefits are associated with improvements to the physical, chemical and biological properties of soil. Furthermore, BCH can affect the growth of phytopathogenic microorganisms. Despite research advances in this area, there is still a lack of information on the effect of BCH concentration on different soilborne microorganisms. This work evaluated the direct effect of sewage sludge biochar (SSB) on the in vitro growth of different soilborne fungi. Eight phytopathogens [Fusarium oxysporum, F. oxysporum f. sp. lycopersici (CEN 1456), Macrophomina phaseolina (429), Sclerotinia sclerotiorum, S. sclerotiorum (CEN 1147), Sclerotium rolfsii (CEN 216), Sclerotium cepivorum (CEN 1357), Rhizoctonia solani] were evaluated. Additionally, a biological control agent [Trichoderma afroharzianum (T-22)] was also studied. Microorganisms were subjected to growth in PDA (Potato-Dextrose-Agar) culture medium enriched with SSB. Biochars, produced at 300 and 500 ºC, were applied at different doses: 0.0 (control), 0.2, 0.4, 0.6, 0.8 and 1.0 (g of SSB/100 ml of PDA). Biochars showed inhibitory effects on the mycelial growth of the different fungi evaluated. It was observed that there is a certain specificity of biochar concentration that must be evaluated for the control of phytopathogens. In most cases, the 0.4 and 0.6% concentrations had a greater inhibitory effect on phytopathogens and did not affect the biological control agent. Therefore, SSB proved to be a promising product for the control of different soilborne phytopathogens.

Biochar and Trichoderma harzianum for the Control of Macrophomina phaseolina

Abstract This study is based on the importance of biological control methods and the lack of information on the effect of biochar (BCH) from sewage sludge associated or not with Trichoderma harzianum on the control of Macrophomina phaseolina in the bean crop (Phaseolus vulgaris, cv. BRS Estilo). Biochar from sewage sludge, pyrolyzed at 500 ºC and used in low concentration (0.5%), has a direct effect on the in vitro control of M. phaseolina. However, higher BCH concentrations stimulated the growth of the pathogen. In culture medium with or without BCH, T. harzianum (strain 1306) inhibited the mycelial growth of M. phaseolina. The addition of BCH + T. harzianum reduced the deleterious effects caused by M. phaseolina on bean plants. This study demonstrated that joint application of BCH from sewage sludge + T. harzianum considerably increased the fresh and dry mass of bean plants, inoculated or not with M. phaseolina.